Wednesday, July 20, 2011

How to Replace a Windshield?

Locate the front windshield.

Inspect the windshield for cracks or shattering.

Remove any body trim pieces such as windshield moldings surrounding the outside lip of the glass.

Remove the windshield from its grove. It is best to use a special removal tool.

After the windshield is removed, remove the seal from its groove and thoroughly remove all broken glass.

Install a thin rope or draw cord around the weather stripping in the flange groove.

Use rubber lubrication to coat the seat for ease of installation.

With an assistant, position the glass and weather stripping over the windshield opening.

Have the assistant apply pressure to the outside of the windshield in the area where the thin rope is being removed.

Pull the rope from the inside of the vehicle out of the flange groove, while pressure is being applied.

Slowly pull the cord out from the entire edge of the windshield. Using your hand, make sure the weather stripping is being pulled over the flange and sealing the windshield.

Install all body trim pieces that were removed.


For more car related problem troubleshooting:---

This are the sections, you can go through and click the link to read its troubleshooting.


The car will not start?


Car will not crank?


Car has no spark?


How to troubleshoot car battery?


How to test starter solenoid?


How to test cars starter?

How to replace starter in car?


car will turn over but will not start?


The Brake Indicator Light Stays On dash of car?

The ABS and Traction Control Lights stays ON dash of car?

Check Engine Light On car?


How to replace Interior Lights on car?

Car lights not working, even after replacing the bulb/lamp?

Click this link below:--


How to replace head lights on car?


How to replace Parking, turn, and Brake Lights on car?
How to remove the door panel on car?

How to replace power window motor in car?

How to test relays on car?


How to troubleshoot Engine Misfires?


The spark plug firing order for car?


Where is the Thermostat located in car?

How to recharge AC on Auto/Truck/car?


How to trouble shoot speedometer?

To Order car parts online:--To get heavy discount on car parts .Click this link below:----

How to Replace Coil Springs?

How to Replace an Oil Pan Gasket?

How to Replace a Fuel Injector

How to Replace a C.O.P. Type Ignition Coil?

How to Replace a Fuel Pressure Regulator?

How to Replace a Fuel Pump?

How to Replace a Rear Lift Gate Locking Mechanism?

How to Clean a Fuel System

How to Replace an Ignition Coil

How to Replace a Mass Air Flow Sensor

No comments:

Post a Comment